Corrosion Behavior Characterization of the Nugget Zone in Copper/Brass Metals of Dissimilar Friction Stir Welded Lap Joints

سال انتشار: 1397
نوع سند: مقاله ژورنالی
زبان: انگلیسی
مشاهده: 295

فایل این مقاله در 8 صفحه با فرمت PDF قابل دریافت می باشد

استخراج به نرم افزارهای پژوهشی:

لینک ثابت به این مقاله:

شناسه ملی سند علمی:

JR_ADMTL-11-1_010

تاریخ نمایه سازی: 13 اردیبهشت 1400

چکیده مقاله:

The electrochemical behavior of the weld nugget zone (WNZ) in copper-brass plates was studied in this paper. These plates were welded by the friction stir lap welding method in ۱M NaCl solution at low heating input (۴۵۰ rpm-۲۵ mm/min ) and  high heating input (۷۱۰ rpm-۱۶ mm/min) by using the electrochemical impedance spectroscopy (EIS) and Tafel polarization at ambient temperature. The morphology of nugget zone corroded surfaces was analyzed by SEM (scanning electron microscopy) technique. The welding process appeared to decrease the corrosion resistance of the welded nugget regions through increasing the welding heat input. The results from EIS measurements presented the welded joints of NZ which showed higher and lower values respectively than brass and copper. Due to changing of microstructural of weld nugget zone during welding process, the Icorr of nugget zone enhances with increasing welding heat input. In fact, the surface corrosion morphology analysis revealed that the surface of welded sample by high heating input was shielded with a roughly porous corrosion layer rather than the surface of the welded sample at low heating input

نویسندگان

kamran amini

Young Researchers and Elite Club, Tiran Branch, Islamic Azad University, Isfahan, Iran Center for Advanced Engineering Research, Majlesi Branch, Islamic Azad University, Isfahan, Iran

Farhad Gharavi

Department of Materials Engineering, Sirjan Branch, Islamic Azad University, Sirjan, Iran

مراجع و منابع این مقاله:

لیست زیر مراجع و منابع استفاده شده در این مقاله را نمایش می دهد. این مراجع به صورت کاملا ماشینی و بر اساس هوش مصنوعی استخراج شده اند و لذا ممکن است دارای اشکالاتی باشند که به مرور زمان دقت استخراج این محتوا افزایش می یابد. مراجعی که مقالات مربوط به آنها در سیویلیکا نمایه شده و پیدا شده اند، به خود مقاله لینک شده اند :
  • Cowie, J. G., Kundig, K. J. A., “Copper and Copper ...
  • Simonović, A. T., Radovanović, M. B., Petrović, M. B., Antonijević, ...
  • Erdem M., “Examining the Structure and Mechanical Properties of Copper-Brass ...
  • Huang, Y. X., Dong, S. S., Zhou, L., Zhou, W. ...
  • Murch, M. G., Templesmith, P., Dawes, C. J., Thomas, W. ...
  • Meran, C., “The Joint Properties of Brass Plates Caused by ...
  • Gharavi, F., Matori, K. A., Yunus, R., and Othman, N. ...
  • Amini, K., Gharavi, F., “The Impact of Welding Speed on ...
  • Tan, K. L., Hsieh, A. K., Feng, Y., Siow, K. ...
  • Ahmed, T. M., Tromans, D., and Alfantazi, A. M., “The ...
  • Kilincceker, G., Erbil, M., “The Effect of Phosphate Ions on ...
  • Burstein, G. T., “Tafel’s Equation: One hundred years (1905–2005)ˮ, Corrosion ...
  • Tuthill, A. H., Todd, B., and Oldfield, J., “Study the ...
  • Griesss, J. C., Bacarella, A. L., “Anodic Dissolution of Cu ...
  • Tromans, D., Silva, J. C., “Copper Behavior in Acidic Sulfate ...
  • Tromans, D., Sun, R., “Anodic Polarization Behavior of Copper in ...
  • Matthews, A., Liu, C., Bi, Q., and Leyland, A., “The ...
  • نمایش کامل مراجع