Effect of Different Kinds of Hydrate Promoters on the Kinetics of Methane Hydrate Formation in Methane-Water-Oil System

In this work, the effect of hydrate promoters on methane hydrate formation in a methane-water-oil system with different initial water cuts from ۲۰ vol% to ۱۰۰ vol% were studied. For comparison, four promoters based on different promotion mechanisms, sodium dodecyl sulfate (SDS), L-leucine (L-l), tetrabutylammonium bromide (TBAB), and polysorbate ۸۰ (Tween ۸۰) were used. The experimental results show that four hydrate promoters did inhibit the nucleation of methane hydrate in ۱۰۰ vol% water cut system, but the growth kinetic of methane hydrate was effectively improved compared with the system without a hydrate promoter. The induction time decreased with the increase of initial water cut under the same concentration of hydrate promoter for the methane-water-oil system, and the total methane consumption used for hydrate formation gradually increased with increasing initial water cut (except Tween۸۰). But the current results also show significant improvement in normalized gas consumption per unit of water content with the increase of oil phase volume fraction that upon addition of oil phase the methane dissolution and mass transfer rate in the methane-water-oil system improve further, meaning that the formation rate of methane hydrate is enhanced. Because of the emulsifying property of Tween ۸۰, the emulsion structure of the systems within Tween ۸۰ hindered the hydrate growth process to some extent. Out of the four hydrate promoters used in this study, SDS was found to be most effective in enhancing the formation kinetic of methane hydrate as well as reducing the induction time in the methane-water-oil system under similar conditions.

کلیدواژه ها:

Methane hydrate ، hydrate promoter ، Induction time ، formation kinetic ، methane-water-oil system