Simulation-based Vibration Sensor Placement for Centrifugal Pump Impeller Fault Detection

سال انتشار: 1399
نوع سند: مقاله ژورنالی
زبان: انگلیسی
مشاهده: 376

فایل این مقاله در 9 صفحه با فرمت PDF قابل دریافت می باشد

استخراج به نرم افزارهای پژوهشی:

لینک ثابت به این مقاله:

شناسه ملی سند علمی:

JR_JCAM-51-1_008

تاریخ نمایه سازی: 31 تیر 1399

چکیده مقاله:

In this paper, a simulation-based method is proposed for optimal placement of vibration sensors for the purpose of fault detection in a centrifugal pump. The centrifugal pump is modeled to investigate the effect of vane tip fault on fluid flow patterns numerically. Pressure pulsations are investigated at different locations at the inner surface of the pump before and after the presence of the fault to determine the best location for installing vibration sensors on the pump casing. Experiments are also conducted by mounting accelerometers at various locations on the pump casing. Simulation and experimental results are then compared and a direct correlation between changes in PSD amplitudes of pressure and acceleration signals was observed. The optimum location for placement of an accelerometer is determined to be near the volute tongue on the casing where the highest level of pressure pulsations in the simulation is also calculated in the presence of vane tip fault.

نویسندگان

Alireza Zabihihesari

Department of Mechanical Engineering, York University, Ontario, Canada

Farzad A. Shirazi

School of Mechanical Engineering, College of Engineering, University of Tehran, Tehran, Iran

Alireza Riasi

School of Mechanical Engineering, College of Engineering, University of Tehran, Tehran, Iran

Mohammad Mahjoob

School of Mechanical Engineering, College of Engineering, University of Tehran, Tehran, Iran

مراجع و منابع این مقاله:

لیست زیر مراجع و منابع استفاده شده در این مقاله را نمایش می دهد. این مراجع به صورت کاملا ماشینی و بر اساس هوش مصنوعی استخراج شده اند و لذا ممکن است دارای اشکالاتی باشند که به مرور زمان دقت استخراج این محتوا افزایش می یابد. مراجعی که مقالات مربوط به آنها در سیویلیکا نمایه شده و پیدا شده اند، به خود مقاله لینک شده اند :
  • E. P. Carden, P. Fanning, Vibration based condition monitoring: a ...
  • J. K. Sinha, K. Elbhbah, A future possibility of vibration ...
  • A. Zabihi-Hesari, S. Ansari-Rad, F. A. Shirazi, M. Ayati, Fault ...
  • F. A. Shirazi, M. Ayati, A. Zabihi-Hesari, S. Ansari-Rad, Fuel ...
  • M. Ayati, F. A. Shirazi, S. Ansari-Rad, A. Zabihihesari, Classification-Based ...
  • R. Isermann, 2011, Fault-diagnosis applications: model-based condition monitoring: actuators, drives, ...
  • S. Orhan, N. Aktürk, V. Celik, Vibration monitoring for defect ...
  • Z. Peng, F. Chu, Application of the wavelet transform in ...
  • A. Jami, Impeller fault detection under fluctuating flow conditions using ...
  • M. Saberi, A. Azadeh, A. Nourmohammadzadeh, P. Pazhoheshfar, Comparing performance ...
  • N. Sakthivel, B. B. Nair, M. Elangovan, V. Sugumaran, S. ...
  • M. Nasiri, M. Mahjoob, H. Vahid-Alizadeh, Vibration signature analysis for ...
  • M. A. S. Al Tobi, G. Bevan, K. Ramachandran, P. ...
  • A. Al-Braik, O. Hamomd, F. Gu, A. Ball, Diagnosis of ...
  • E. Niazi, M. Mahjoob, A. Bangian, Experimental and numerical study ...
  • A. A. Abdel Fatah, M. A. Hassan, M. Lotfy, A. ...
  • R. Spence, J. Amaral-Teixeira, Investigation into pressure pulsations in a ...
  • J. Gonza´ lez, J. n. Ferna´ ndez, E. Blanco, C. ...
  • C. Mullen, T. Vaughan, M. Voisin, M. Brennan, P. Layrolle, ...
  • R. Barrio, J. Parrondo, E. Blanco, Numerical analysis of the ...
  • A. A. Noon, M.-H. Kim, Erosion wear on centrifugal pump ...
  • K. Guleren, A. Pinarbasi, Numerical simulation of the stalled flow ...
  • Y. Fu, J. Yuan, S. Yuan, G. Pace, L. d ...
  • K. Cheah, T. Lee, S. Winoto, Z. Zhao, Numerical flow ...
  • L. Obregon, G. Valencia, J. D. Forero, Efficiency Optimization Study ...
  • نمایش کامل مراجع